BOAC Flight 712
The burning 707-465, showing the empennage's (tail section's) skin melted by the fire to expose the interior of the tail.
|Date||8 April 1968|
|Site||Hounslow, United Kingdom|
|Aircraft type||Boeing 707-465|
|Aircraft name||Whisky Echo|
|Flight origin||London Heathrow Airport
Middlesex, United Kingdom
|1st stopover||Zürich Airport
|2nd stopover||Singapore International Airport, Singapore|
BOAC Flight 712 (callsign Speedbird 712) was a British Overseas Airways Corporation service operated by a Boeing 707-465 from London Heathrow Airport bound for Sydney, Australia via Zurich and Singapore. On Monday 8 April 1968, it suffered an engine failure on takeoff that quickly led to a major fire. The engine fell off the aircraft in flight. After the aircraft had made a successful emergency landing, confusion over checklists and distractions from the presence of a check captain contributed to the deaths of five of the 127 on board.
The actions taken by those involved in the accident resulted in the award of a George Cross, a British Empire Medal and an MBE. As a direct result of the accident, BOAC changed the checklists for engine severe failures and engine fires, combining them both into one checklist, the "engine fire or severe failure" checklist.
Flight 712 took off from Heathrow at 15:27 GMT (16:27 BST), 12 minutes later than scheduled.1 Flight 712 had 127 people aboard, including a crew augmented by the addition of an acting flight officer, John Hutchinson, and a check captain for routine performance review of the pilot in command, Captain Taylor. As well as the passengers, the aircraft was carrying baggage, mail and a radioactive isotope from the Isotope Production Unit at Harwell destined for the University Hospital in Jerusalem.2
Seconds after take off from Heathrow's then 9,000 feet (2,700 m) long runway 28L (now 12,008-foot (3,660 m) long and designated 27L),3 there was an unexpected bang and the aircraft started vibrating. The throttle controlling number two engine was shutting down. While Captain Taylor ordered an engine failure drill, Flight Engineer Thomas Hicks carried out the engine failure drill, but both he and Check Captain Geoffrey Moss reached for the switch to cancel the undercarriage warning horn. At the same time, First Officer Francis Kirkland inadvertently cancelled the fire bell. Hicks reached for, but didn't pull, the engine fire shut-off handle. Moss, observing the fire, exclaimed "Bloody Hell! The wing's on Fire!"2 A Mayday was broadcast at 15:29.1
In the control tower, the takeoff had been observed by John Davis, who saw what he initially thought was the sun reflecting off the aircraft's wing during its initial climb. Davis quickly realised that the aircraft was on fire. Davis instructed Flight 712 to make a left turn, with the intention that the aircraft would land on runway 28L.4 He hit the "crash button" which alerted the emergency services and declared an aircraft accident. The emergency services were informed of the type of aircraft involved and given a rendezvous point at which they were to assemble.2
By this time, the windows on the port side at the rear of the fuselage were beginning to melt. As the aircraft flew over Thorpe the burning engine broke away from its mounting and fell into a gravel pit where some children were playing, without causing any injury.2 At this time, the undercarriage was lowered and full flap selected. The flaps stopped some three degrees short of their full travel. The aircraft was at a height of 3,000 feet (910 m) and flying at 225 knots (417 km/h)5 Stewardess Jennifer Suares repeated the emergency landing drill for the benefit of the passengers despite not being sure herself that they would actually manage to land before the aircraft exploded.2
The crew realised that the aircraft would not last long enough to enable a landing back on 28L, and declared a Mayday. Davis cleared the aircraft to land on runway 05R,4 which was 7,733 feet (2,357 m) long.6 He also instructed two other aircraft to perform a go-around, as runway 05R crossed runway 28R, which they were due to land on and Davis did not know whether Flight 712 would be able to stop before reaching that runway.4 The crew accepted Davis's offer of runway 05R, even though it was much shorter and not equipped with ILS.2 Taylor was able to safely land the aircraft on 05R, using wheel brakes and reversing the outboard engines' thrust to halt the aircraft.7 The aircraft touched down about 400 yards (370 m) beyond the threshold and stopped in 1,400 yards (1,300 m).5 The aircraft had made a perfect emergency landing after just 3m:32s of flight. Taylor asked Davis for permission to evacuate, but the cabin crew were already opening the emergency doors.2 The flight crew started the fire drill, but the port wing exploded before this could be completed. As a result, the fire shut off handles were not pulled, and the booster pumps and electrical supply were left switched on.5 Due to the short period of time between the Mayday being declared at 15:29 and the aircraft landing at 15:31, there was no time for the emergency services to lay a carpet of foam, which was standard practice at the time.1
The cabin crew started the evacuation via both forward galley doors, both rear doors and the starboard overwing exits. Eighteen passengers escaped via the overwing exits before the fire grew too intense to use that route. The forward port galley door escape slide caught fire before it could be used, but one person jumped from there. Eighty-four people escaped via the starboard galley door. Three of the crew escaped by the emergency cockpit rope. The rear starboard door escape slide had twisted on deployment, so Steward Taylor climbed down to straighten it, leaving stewardess Barbara Jane Harrison at the door assisting the passengers. Six passengers escaped via this route before the slide was punctured and deflated. Harrison encouraged the passengers to jump, and pushed out those too frightened to do so. Eleven people escaped via this route, and five more escaped via the rear port door before the slide was destroyed. Harrison was last seen alive preparing to jump herself, but then she turned back and disappeared into the burning fuselage.28 It was this action which led to the award of a George Cross to Harrison.9 Thirty-eight people were injured, and five killed.7
The first two fire engines to arrive were unable to do much to stop the fire, as the drivers misjudged their distance, and also they were unable to make foam whilst on the move. To make foam, the main transfer gearboxes of the fire engines had to be operated, which meant that the vehicles were unable to move. Problems with couplings on the fire hoses exacerbated the situation - the fire hydrants had been regularly painted, and a build up of paint on the coupling threads prevented the hoses from being attached to the hydrants. The driver of a back-up foam tender drove in closer to the burning aircraft and discharged his foam effectively, but the fire had already gained hold by the time this happened.10
Another notable survivor was Katriel Katz, Israeli Ambassador to the Soviet Union. Katz had been expelled from the Soviet Union by Andrei Gromyko when it became clear that the Six-Day War would happen. Gromyko is said to have told Katz not to let his emotions get the better of him, advice he was to ignore in the emergency that was to befall him.12 During the evacuation from the aircraft, Katz was the only passenger to escape through the forward port door, despite the efforts of Hutchinson and Unwin to stop him using that door. The two flight crew were almost carried out through the door by Katz, who was a large man. Katz was seriously injured jumping from the doorway.11 He was taken to Hillingdon Hospital, where it was initially feared that he would become the sixth victim of Flight 712. Katz recovered after a few days. He died in 1988 aged 80.13
The aircraft involved in the accident was a Boeing 707-465 registered G-ARWE (manufacturer's serial number 18373, Boeing line number 302).5 First flown on 27 June 1962, the aircraft was originally to have been operated by Cunard Eagle Airways, but before it entered service it was sold to BOAC-Cunard and was delivered on 7 July 1962. On 21 November 1967, the aircraft suffered an engine failure on take off from Honolulu International Airport. The take off was aborted, and there were no injuries to any of the passengers or crew.14 At the time of the Heathrow accident, the aircraft had flown for a total of 20,870 hours.5 The aircraft was insured for £2,200,000 with Lloyd's of London.15
The nose section of G-ARWE was salvaged, and used on a Boeing 707-331B, TWA's N28714,2 c/n 18408.16 The recipient aircraft was previously registered N776TW, which had been hijacked on a flight from Rome to Athens. Its cockpit had been destroyed by a bomb at Damascus, Syria, on 29 August 1968. The rest of the airframe was found to be undamaged. The nose section of G-ARWE remained intact after the fire, and thus was fitted to N776TW. That aircraft was test flown on 4 December 1969 and flew with TWA for another ten years as N28714. In March 1980 it was withdrawn from service and stored at Kansas City International Airport. In 1983 it was sold to Boeing and flown to Davis–Monthan Air Force Base for use as spares for the United States Air Force KC-135 Stratotanker fleet. N28714's registration was cancelled in March 1984.17 The majority of the aircraft, including the nose section, was still intact at Davis-Monthan as of 2 December 2012.18
In the subsequent investigation, metal fatigue was ultimately blamed for the failure of the number five compressor wheel in the number two Rolls Royce 508 Conway turbofan engine,7 starting the rapid chain of failures. The crew's omitting to shut off the fuel to the engine was blamed for the rapid growth of the fire and the loss of the aircraft.5 Check Captain Moss had accidentally cancelled the fire warning bell instead of the undercarriage warning bell. Moss had also issued orders to Captain Taylor, in breach of the normal protocol for his duties. However, the report on the accident also stated that Captain Taylor had briefed Moss to act as an extra set of eyes and ears inside and outside the cockpit. Moss's actions therefore could be seen as acting within that remit.419
As a result of the investigation, and lessons learned from the chain of events, BOAC combined the "Engine Fire Drill" and "Engine Severe Failure Drill" checklists into one list, called the "Engine Fire or Severe Failure Drill". Modifications were also made to the checklist, including adding confirmation that the fire handles had been pulled to the checklist.8
Queen Elizabeth II awarded Barbara Jane Harrison a posthumous George Cross (GC), the only GC ever presented to a woman in peacetime.9 Her medal was accepted on her behalf by her father, Alan.2 Harrison is the youngest ever female recipient of the George Cross.20 Neville Davis-Gordon was awarded the British Empire Medal for Gallantry (BEM).9 John Davis was appointed a Member of the Most Excellent Order of the British Empire (MBE).2
On April 8th 1968, soon after take-off from Heathrow Airport, No. 2 engine of B.O.A.C. Boeing 707 G-ARWE caught fire and subsequently fell from the aircraft, leaving a fierce fire burning at No. 2 engine position. About two and a half minutes later the aircraft made an emergency landing at the airport and the fire on the port wing intensified. Miss Harrison was one of the stewardesses in this aircraft and the duties assigned to her in an emergency were to help the steward at the aft station to open the appropriate rear door and inflate the escape chute and then to assist the passengers at the rear of the aircraft to leave in an orderly manner. When the aircraft landed Miss Harrison and the steward concerned opened the rear galley door and inflated the chute, which unfortunately became twisted on the way down so that the steward had to climb down it to straighten it before it could be used. Once out of the aircraft he was unable to return; hence Miss Harrison was left alone to the task of shepherding passengers to the rear door and helping them out of the aircraft. She encouraged some passengers to jump from the machine and pushed out others. With flames and explosions all around her and escape from the tail of the machine impossible she directed her passengers to another exit while she remained at her post. She was finally overcome while trying to save an elderly cripple who was seated in one of the last rows and whose body was found close to that of the stewardess. Miss Harrison was a very brave young lady who gave her life in her utter devotion to duty.
|“||Award of the British Empire Medal for Gallantry (Civil Division)
On April 8th 1968, soon after take-off from Heathrow Airport, No. 2 engine of B.O.A.C. Boeing 707 G-ARWE caught fire, and subsequently fell from the aircraft, leaving a fierce fire burning at the No. 2 engine position. About two and a half minutes later the aircraft made an emergency landing at the airport and the fire on the port wing intensified. Mr. Davis-Gordon was Chief Steward aboard the aircraft, under his command, the cabin staff successfully organised the escape of 112 passengers, from a total of 116 from the burning aircraft. The Chief Steward's firm and calm instructions not only guided passengers to the most appropriate exit, but clearly helped to avoid any panic. On one occasion it was necessary for Mr. Davis-Gordon to get out on to the starboard wing to assist a passenger who had become stranded there because of the spread of the fire. He helped her back, re-entered the aircraft and directed her to a safe escape exit at the front of the aircraft. By remaining on the aircraft until he was satisfied all survivors had left the main cabin, he risked his life in the knowledge that a further explosion might occur at any moment and engulf the aircraft. His coolness and qualities of leadership were of a high order and an inspiration to his cabin staff, who themselves displayed high qualities of devotion to duty in spite of the obvious perils of the situation.
Other accidents in which aircrew were decorated include:
- United Airlines Flight 232
- Alrosa Mirny Air Enterprise Flight 514
- 2003 Baghdad DHL attempted shootdown incident
- US Airways Flight 1549
- "121 Escape as blazing Boeing crashes at Heathrow" The Times (London). Tuesday, 9 April 1968. (57222), col A, p. 1.
- O'Brien, Tim (June 2008). "The Last Flight of Whiskey Echo". Aeroplane. 36, Number 6 (422): p30–35. ISSN 0143-7240.
- "BACKGROUND AND HISTORY OF HEATHROW AIRPORT". Miles faster. Retrieved 5 April 2010.
- Ottaway, Susan (2008). "Chapter 4, The Last Flight of Whiskey Echo". Fire over Heathrow, The Tragedy of Flight 712. Barnsley: Pen and Sword Books. pp. p40–61. ISBN 978-1-84415-739-6.
- Accident description at the Aviation Safety Network. Retrieved on 26 March 2008
- "Super VC10 Navigation & Performance Manual". VC10.net. Retrieved 7 April 2010.
- "Special Report: British Overseas Airline Company Flight 712". Air Disaster. Archived from the original on 17 April 2008. Retrieved 26 March 2008. NB: Report has wrong date and wrong direction of flight 'over Hounslow'
- Job, MacArthur (1994). Air Disaster 1. Weston Creek, ACT: Aerospace Publications. p. p60–66. ISBN 1-875671-11-0.
- The London Gazette: . 7 August 1969. Retrieved 16 May 2008. The citation for Harrison's GC is on p.1, Davis-Gordon's BEM is on p.3
- Duncan, Stephen (January 2009). "Heathrow 707 fire". Aeroplane 37 (1): p98–99. ISSN 0143-7240.
- Ottaway, Susan (2008). "Chapter 5, The Tragedy of Flight 712". Fire over Heathrow, The Tragedy of Flight 712. Barnsley: Pen and Sword Books. pp. p62–77. ISBN 978-1-84415-739-6.
- Ottaway, Susan (2008). "Chapter 3, The Final Briefing". Fire over Heathrow, The Tragedy of Flight 712. Barnsley: Pen and Sword Books. pp. p19–39. ISBN 978-1-84415-739-6.
- Ottaway, Susan (2008). "Chapter 6, The Evening News". Fire over Heathrow, The Tragedy of Flight 712. Barnsley: Pen and Sword Books. pp. p78–91. ISBN 978-1-84415-739-6.
- "NTSB Identification: OAK68A0046". National Transportation Safety Board. Retrieved 15 May 2008.
- "Jet crash: £2m insurance bill" The Times (London). Wednesday, 10 April 1968. (57223), col F, p. 211.
- "FAA Registry N-Number Inquiry Results". Federal Aviation Administration. Retrieved 15 May 2008.
- Ottaway, Susan (2008). "Appendix 4, The Fate of Whiskey Echo". Fire over Heathrow, The Tragedy of Flight 712. Barnsley: Pen and Sword Books. pp. p168–69. ISBN 978-1-84415-739-6.
- Porsch, Thomas (2 December 2012). "Photo: N28714 C/N 18408". Vienna-Aviation-Photography/Jetphotos.net. Retrieved 19 September 2013.
- Ottaway, Susan (2008). "Chapter 8, Replacements, investigations and Reports". Fire over Heathrow, The Tragedy of Flight 712. Barnsley: Pen and Sword Books. pp. p105–29. ISBN 978-1-84415-739-6.
- "The Decoration, Facts and Statistics and Information about the Exchanges: The George Cross". George Cross Database. Retrieved 20 March 2010.
- Crown copyright
- Ottaway, Susan (2008). Fire over Heathrow: The Tragedy of Flight 712. Barnsley: Pen and Sword Books Ltd. ISBN 978-1-84415-739-6.
- Barbara Jane Harrison's George Cross details.